2017 Ford F-150
Mileage
115,330
Service Date
10/16/2024
Services Performed
- Complete hookup & analysis on Scope or Scanner 1. Confirm problem : yes 2. Monitors : N/A 3. Computer codes : P-0330 Knock/combustion vibration sensor 2 bank 2 C-0031-12 Left front wheel speed sensor circuit short to battery C-0031-14 Front wheel speed sensor circuit short to ground. B1182, B124D-02, TPMS, TPMS sensor general failure U-0415 invalid data received from anti lock brake system 4. Mode 6 data: Pass/Fail – Info – 5. Visual test : fail 6. Engine vac. @ idle : N/A 7. Engine vac. @ 2500 : N/A 8. Smoke test : N/A 9. Diagnostics : Scanned for codes and found knock sensor/wheel speed sensor/ABS/TPMS codes. Need to remove intake manifold to access knock sensors for further diagnostic. After removal found chewed wires at sensor/sensor harness. R&R knock sensor/harness cleared codes and road tested vehicle. No Knock sensor issues at this time. Scanned for invalid data from ABS module, likely caused by wheel speed sensor short. Visually inspected sensor found rodent damage to wiring at the sensor plug. R&R sensor/harness cleared codes and road tested. No ABS/wheel speed codes at this time. Scanned for tpms sensors, no communication with scanner, likely batteries have worn out and units need to be replaced. R&R sensors with customer supplied sensors, no issues at this time. Nothing to fully explain lag in performance, recommend looking at fuel injectors. 10. Confirm fix: YES Tire Pressure F= 36 R= 36
- Changed oil and oil filter. Lube Chassis & Driveline Check sheet: Transmission fluid: ok Radiator water: ok Windshield wiper fluid: ok Wiper Blades ok Battery water: ok Battery Date code_____4/22______ Brake fluid ok Hyd. clutch fluid: n/a PS fluid: ok Air filter: ok Cabin Filter: n/a Belts: ok Hoses: ok Shocks & suspension: ok Chassis lubrication: ok Oil leaks: ok Lights: ok Tires: ok Date codes: '20 Tread depth(MM) – LF____5______RF____5______LR_____7_____RR_____7_____ Air Pressure F=____36______R=____36______ Visual Brake inspection(MM) F=_____________ R=_____7______ Oil Sticker: Door RESET OIL LIFE MONITOR___yes______
- SPARK PLUGS – Remove & Replace – 2.7L Eng
- A/C COMPRESSOR DRIVE BELT – Remove & Replace – 2.7L Eng
- RADIATOR HOSE – Remove & Replace – 2.7L Eng Both
- THERMOSTAT &/OR GASKET – Remove & Replace – 2.7L Eng
- Ultrasonic clean 8 injectors Install on flow bench & hook up wiring connectors Flow test @ idle, 1800, 2500 & 5000 – record numbers Measure & record electrical resistance Install new injector filter/baskets & O'rings Fill out injector service diagnostic report Found injector 4 and 6 to be leaking- recommend replacement.
- ENGINE KNOCK SENSOR & repair wiring, Remove & Replace – 2.7L Eng One or Both – [Includes: R&I Fuel Rail.] – [Includes: Component test.]
- WHEEL SPEED ABS SENSOR – Remove & Replace – Front,One Side
- TIRE PRESSURE SENSOR – Remove & Replace – Four – [Includes: Perform Relearn procedure.]- customer supplied sensors from old tires.
- TRANSMISSION OIL FILTER – Remove & Replace
Kyle M. gave our service a 5 star review on 10/16/2024
